Downstream Air Filters
KNOWING THE RIGHT ANSWER...There are some industry sectors that cannot accept anything less than high quality compressed air. Such Industries can rely on BOGE to provide specialist professional advice in the selection of the correct air treatment system to suit their specifi c needs and, to meet the required air quality in the most cost effective manner!
THE RIGHT SYSTEM FOR YOUR REQUIREMENT...Based on your air quality requirements BOGE will take care of selecting the appropriate air treatment products to provide an optimal solution from initial assessment to system design. You are invited to contact our experts for a consultation!
FOR ULTRA CLEAN COMPRESSED AIR IN EXTREME CONDITIONS...Compressed air treatment is achieved in several stages. Pre-fi lters are used to separate coarse impurities from the compressed air. Smaller solids and oil can be removed by means of microfilters. Finally active carbon fi lters are used to clean oil vapours, aromatics, flavourings and odours from the compressed air. This assures oil free and clean compressed air even in extreme conditions
MAINTENANCE FREE FILTRATION...The BOGE heavy-duty cyclone separators takes liquids, aerosols and solids from the compressed air. Based on the law of inertia they operate with practically no maintenance – ideally suited for compressed air systems without an air receiver when directly installed downstream of the compressor.
FLOW CAPACITY: 10-2180CFM.
Air Filter - Series Z
Product Details:
| Minimum Order Quantity | 1 Unit |
| Filter Type | Cartridge Filter |
| Filtration Grade | Medium Filter |
| Max Temperature (Degrees F) | 100-150 |
| Condition | New |
- Operating Principle- The cyclone separator is ideally suited as a bulk water separator when located before a refrigerant dryer or directly after the compressor if no air receiver is used; or if it is placed at a distance; or if the compressed air supply pipe is mounted vertically.
- Minimal-Pressure-There is a minimal pressure loss across a cyclone separator which means that operating pressure is always optimized saving energy.
- Efficiency-Apart from the drain, the cyclone separator operates wear free because there are no moving parts which mean increased output of the compressed air treatment system.
The cyclone separator works according to the mass inertia principle. It consists of a vortex cartridge and a reservoir. The vortex cartridge induces the compressed air into rotary movement. Solid and liquid components in the air are forced against the inside walls of the separator by their own mass inertia. This causes heavy particles of dirt and water to separate and flow into the collection reservoir.
Callback
Micro/Carbon Filter - Series-FP/A
Product Details:
| Minimum Order Quantity | 1 Piece on words |
| Flow Capacity | 17-2180 cfm |
| Use | Pneumatic Equipment |
| Driven Type | Electric |
| Power | 25 kW |
- For ultra-clean compressed air inn extreme conditions: Compressed air treatment is achieved in several stages. Pre-filters are used to separate coarse impurities from the compressed air. Smaller solids and oil can be removed by means of microfilters. Finally, active carbon filters are used to clean oil vapours, aromatics, flavourings and odours from the compressed air. This assures oil free and clean compressed air even in extreme conditions!
- Boge Micro filter Series FP: Microfilters separate out extremely fine impurities in the compressed air. BOGE microfilters remove solids from compressed air with an efficiency of 99.99999% relative to 0.01 μm and a residual oil content up to 0.01 mg/m3. Cost-efficient use of BOGE microfilters
- Boge Activated Carbon Filter Series A: Activated carbon filters remove flavours and odours from the compressed air. In combination with BOGE microfilters, BOGE activated carbon filters remove solids from compressed air with an efficiency of 99.99999% relative to 0.01 μm and a residual oil content of up to 0.005 mg/m3. Cost-efficient use of BOGE activated carbon filters.
- Downstream from compressed air dryers, in combination with microfilters.
Callback
Air Filter - Series V
Product Details:
| Minimum Order Quantity | 1 Piece |
| Usage | Air Filter |
| Weight of Filtering Material | 0-200 kg, 200-400 kg, 400-800 kg, 800-1200 kg, >1200 kg |
| Condition | New |
PRE-FILTER SERIES V EFFICIENT-BOGE pre-fi lters are 99.99 percent efficient based on 3 μm, thus providing optimal conditions for further compressed air treatment.
LAYOUT-It is recommended that a pre-fi lter is positioned upstream of the compressed air dryer and the microfi lter. They are essential when ambient air is extremely dusty or when high oil carry over is a risk.
Callback
